Nissan Patrol and Ford Maverik
+ Cars of the Nissan Patrol and Ford Maverick series
+ Diagnostics of malfunctions
- Settings and routine maintenance
Greasing and service
Procedures of service of wheels
Schedule of routine maintenance of the car
Settings of the engine and description of the main procedures of its service
+ Engine
+ Systems of cooling, heating and air conditioning
+ the Power supply system and production of the fulfilled gases
+ Systems of decrease in toxicity of the fulfilled gases
+ Systems of electric equipment of the engine
+ Transmission
+ Coupling
+ Brake system
+ Forward and back bridges, running gear and steering
+ Body
+ Onboard electric equipment
|
Schedule of routine maintenance of the car
|
|
Brought to attention of readers the schedule of routine maintenance belongs to the cars maintained in normal conditions. At vehicle operation in any of listed below conditions intervals of service it is necessary to reduce a minimum by 5 %:
- Trailer towage, or transportation of heavy cargoes;
- Operation in the conditions of a strong dust content, dirt and influence of hostile environment;
- Frequent trips to a cold season on distance of not exceeding 8 km;
- Frequent distant trips with small speeds of movement or with the long periods of operation of the engine on single turns.
|
Weekly or through each 1 000 km of run (during each filling of the car by fuel)
|
|
Check level of impellent oil. In case of need add.
Check level of cooling liquid. In case of need add.
Check liquid level in the main cylinder of coupling. In case of need add.
Check level of liquid of system of hydrostrengthening of a wheel. In case of need add.
Check GTTs liquid level. In case of need add.
Check electrolit level in the battery (not more rare than once a month). In case of need add the distilled water.
Check and correct pressure of a rating of tires (at cold wheels). At the same time it is meaningful to estimate visually degree of wear of a protector and existence in it got stuck strangers of subjects. The chart of an assessment of a condition of tires is provided in the section devoted to diagnostics of malfunctions of tires.
|
|
Time in 6 months or through each 10 000 km of run
|
|
Make replacement of impellent oil and the oil filter.
Check a condition of components of system of production of the fulfilled gases.
Check a condition of a filtering element of an air purifier. In case of need clean an element, or make its replacement.
Check a free wheeling of a pedal of coupling. In case of need carry out adjustment. also check serviceability of functioning of coupling.
Check hydraulic system of coupling on existence of signs of leaks and destruction of lines as a result of material aging.
Check oil level in transmission and a transfer case.
Check oil level in differentials of both bridges.
Estimate degree of wear of crosspieces of driveshafts, make stuffing of hinges by greasing.
Check a condition of spherical hinges of driving drafts of a steering, make stuffing them greasing.
Check hydraulic system of the steering amplifier on existence of signs of leaks and destruction of hoses as a result of material aging.
Check a condition of brake shoes, disks, supports and hydraulic lines. Check hydraulic system on existence of signs of leaks.
Check serviceability of functioning of foot and lay brakes.
Check serviceability of functioning of all onboard electric equipment, including a horn, lighting devices, screen wipers and washers. Grease loops and locks of all doors.
|
|
Once a year or through each 20 000 km of run
|
|
All listed above check, plus:
Check a condition and a tension of driving belts in an impellent compartment. In case of need make replacement or tension adjustment.
On models of 4.2 l check gaps of valves, carry out necessary adjustment.
Check a condition of all hoses of systems of cooling/heating. Make necessary replacements.
Check installations of turns and quality of a mix of idling. In case of need make adjustments.
Check serviceability of functioning starting an automatic equipment/drive of an air zaslonka.
Check serviceability of functioning of system of operated ventilation of a case (PCV).
Check serviceability of functioning of the automatic device management of heating of air soaked up in an air purifier.
Check a condition of naves with a disconnected drive and stupichny bearings of forward wheels. In case of need make stuffing them greasing.
Check a condition of the shock-absorber of the steering mechanism.
On the cars equipped with drum-type brake mechanisms, check a condition of boots, drums and wheel cylinders. Make necessary replacements.
Make replacement of spark plugs.
On models of 4.2 l replace contacts of the breaker of the distributor.
Tighten bolts of fastening of elements of a body.
Check a condition, reliability of fastening and serviceability of functioning of anchors, buckles and returnable mechanisms of seat belts. Estimate degree of wear of tapes of belts.
Check corners of installation of wheels. In case of need carry out rotation or balancing of wheels.
|
|
Time in 2 years or through each 40 000 km of run
|
|
All listed above check, plus:
Empty cooling system, wash out it and fill with fresh cooling liquid.
Make replacement of a filtering element of an air purifier.
Periodically remove a rubber cover from a cyclonic pyleotdelitel of preliminary purification of air and delete from it the accumulated dust. Time in 2 years make obligatory cleaning of a cyclonic pyleotdelitel.
Make replacement of the fuel filter.
Check fuel lines and their shtutserny connections on existence of signs of leaks. Replace defective components.
Make PCV filter replacement.
Check a condition of hoses and shtutserny connections of system of catching паров fuels. Make replacement of defective components.
Make replacement of liquid of a hydraulic drive of coupling.
On models from RKPP Make replacement of transmission oil.
On models from AT, if the car is maintained in intense conditions (see the prevention at the beginning of the Section), make ATF replacement.
Make replacement of oil of a transfer case.
Make replacement of liquid of differentials of both bridges.
Make stuffing of stupichny bearings and hinges of power shafts of the forward bridge.
Check a condition of vacuum hoses and the control valve of the amplifier of brakes.
Check a condition of VV of wires, make necessary replacements.
|
|
|
|